VIEW MORE PLS CONTACT US >>>
Q:Motor has been running then fails to start,what to do?
A:Likely cause: Fuse or circuit breaker is tripped.
What to do: Replace the fuse or reset the breaker.
Likely cause: Armature is shorted. Motor may make a humming noise and the circuit breaker or fuse will trip.
What to do: Disassemble motor and inspect the armature for a burnt coil. Inspect the commutator for burnt bars. If this condition exists, the motor needs to be replaced.
Likely cause: The brushes may be worn down too far and no longer make contact with the commutator.
What to do: Check the brushes to make sure that they are still making contact with the commutator. Contact manufacturer for brushes.
Likely cause: Controller may be defective.
What to do: Verify voltage is coming out of the controller.
Q: On initial installation, motor fails to start up,what to do?
A: Likely cause: Motor is incorrectly wired
What to do: Verify that the motor is wired correctly.
Likely cause: No output power from controller.
What to do: Measure voltage coming from the controller.
Likely cause: Motor is damaged and the armature is rubbing against the magnets.
What to do: Disassemble motor and see if the armature can be realigned by reassembly. Motor may have to be replaced.
Q: Motor takes too long to accelerate,what to do?
A: Likely cause: Motor controller not properly set.
What to do: Adjust the acceleration trim pot of the controller.
Likely cause: Brushes are worn.
What to do: Verify brush length.
Likely cause: Bearings may be defective.
What to do: Inspect bearings. Noisy or rough bearings should be replaced.
Q: Motor runs in the wrong direction,what to do?
A: Likely cause: Incorrect wiring
What to do: Interchange the two motor leads.
Q: Motor runs OK but has a clicking noise,what to do?
A: Likely cause: Suspect a burr on the commutator.
What to do: Remove burr from commutator using a commutator stone.
You May Like
- HFM023 24v 1200w 2300rpm 4.98Nm 58.82Amp B3 B14 B34 B5 hall sensor bldc brushless dc motor for electric traffic jam
- HFM024 24V 375W 1625RPM 2.20Nm 18.38Amp B3 B14 NEMA 56C gate operator hall sensor brushless dc bldc motor for a gate operator
- HFM025 48V 750W 1000RPM 7.16Nm 18.38Amp B3 B14 B34 B5 BLDC Controller brushless dc motor for belt drive system
- HFM026 300VDC 370W 1500RPM 2.36Nm 1.45Amp B3 B14 B34 B5 BLDC motors ac brushless dc motor for drill
- HFM027 12v 600w 1500rpm 3.82Nm 58.82Amp B3 B14 B34 B5 BLDC motors with hall sensor
- HFM032 24v 750w 3500rpm 2.04Nm 36.76Amp B3 B14 B34 B5 hall sensor bldc brushless dc controller motor for Home Appliance
- HFM034 48V 4000W 6000RPM 6.37Nm 98.04Amp B3 B14 B34 B5 Controller BLDC brushless dc motor for green energy resource
- HFM035 24V 300W 1500RPM 1.91Nm 14.71Amp B3 B14 B34 B5 BLDC Motor BRushless dc motor with driver KBS24101X
- HFM036 48V 750W 3000RPM 2.39Nm 18.39Amp Hall sensor BLDC brushless dc motor for Green and energy-saving car race
- HFM038 48V 4000W 1800RPM 21.22Nm 98.04Amp B3 B14 B34 B5 Controller BLDC BRUSHLESS DC MOTOR FOR Grinding and polishing equipment
Popular Searches
Find Similar Products By Category
You May Like
- HFM039 24V 1300W 2000RPM 6.21Nm 63.73Amp B3 B14 B34 B5 Controller BLDC Brushless DC Motor for vacuum pump
- HFM040 24V 1500W 3500RPM 4.09Nm 73.53Amp B3 B14 B34 B5 BLDC Controller brushless dc motor for Home Appliance
- HFM043 220Vac 4500W 3000RPM 14.33Nm 24.06Amp controller BLDC brushless dc motor for water pump
- HFM044 24V 2000W 3000RPM 6.37Nm 98.04Amp B3 BLDC Brushless dc motor
- HFM044 24V 2000W 3000RPM 6.37Nm 98.04Amp B3 B14 B34 B5 controller BLDC for Traction drive
- EMP043 48V 4000W 2580RPM B14 with controller and hall sensor 24mm shaft diameter
- EMP043 48V 4000W 2580RPM B14 with controller and hall sensor 24mm shaft diameter
- EMP044 48V 1500W 3000RPM with controller high torque brushless bldc hall sensor dc motor
- EMP044 48V 1500W 3000RPM with controller high torque brushless bldc hall sensor dc motor
- HFM046 220V 4500W 3000RPM 14.33Nm 24.06Amp B3 B14 B34 B5 BLDC Brushless dc motor with 1024ppr magnetic encoder Divyesh
- HFM046 300VDC 4500W 3000RPM 14.33Nm 24.06Amp B3 B14 B34 B5 1024ppr magnetic brushless bldc motor with encoder
- HFM048-V03 48V 160W 3000RPM 0.51Nm 3.92Amp B3 B14 B34 B5 BLDC Brushless dc motor
- HFM049 24V 1500W 1500RPM 9.55Nm 73.53Amp B3 B14 B34 B5 BLDC Jeol brushless dc motor for vacuum pump
- HFM050 380V 1.5KW 1500W 650RPM 22.04Nm 4.64Amp B3 B14 B34 B5 BLDC Mihir brushless dc motor for draught fan
- HFM051 48V 600W 1800RPM 3.18Nm 14.71Amp B3 B14 B34 B5 BLDC brushless dc motor for motor racing